稻草和毛竹CO2 超临界流体萃取脱木质素研究
Delignification of bamboo and straw using CO2 supercritical fluid extraction technology
-
摘要: 采用CO2超临界流体萃取技术脱除稻草和毛竹的木质素, 利用正交试验对脱木质素率与综纤维素含量等指标进行了评价;采用气相色谱--质谱联用方法（GC--MS）分析了萃取液的组成,讨论了萃取液组成与萃取条件（温度、压力和时间）的关系;利用透射电镜--能谱联用技术（TEM--EDXA）考察了萃取前后材料中木质素分布的超微结构。结果表明：温度、压力和时间是影响稻草和毛竹脱木质素的主要因素；温度越高、压力越大、时间越长，脱木质素程度越大，综纤维素含量越低。萃取液中主要含有来自纤维素结构的五元环、烷氧基醇和脂肪酸以及来自于H、G、S型木质素典型结构单元的降解产物。经CO2超临界萃取后，在160 ℃、16 MPa、60 min条件下，稻草细胞壁分层已不明显；在200 ℃、16 MPa、60 min条件下，毛竹细胞壁胞间层和细胞角隅中的木质素已全部溶出。
-
关键词:
- 脱木质素 /
- 超微结构 /
- 毛竹 /
- 稻草 /
- CO2超临界流体 /
- 气相色谱--质谱联用方法 /
- 透射电镜--能谱联用技术
Abstract: A technology of CO2 supercritical fluid extraction was adopted to remove the lignin in straw and bamboo. The content of Klason lignin and holocellulose was evaluated through orthogonal experiments. Extraction liquid composition was analyzed by GC/MS. The relationship between extraction liquid composition and experimental conditions was discussed. The ultrastructure of lignin distribution before and after extraction was analyzed by transmission electron microscopy(TEM) and energy dispersive X-ray analysis(EDXA). Results showed that temperature and time were major factors affecting delignification of straw and bamboo. The higher the temperature and the longer the time, the higher the delignification and the lower the holocellulose content. The extraction liquid consisted of five-membered rings, alkoxyl groups and aliphatic acids from cellulose and lignin degradation products(H-, G- and S-type structure units). TEM-EDXA analysis showed that after CO2 supercritical fluid extraction, cell wall delamination of straw was unobvious and the lignin of middle lamella and CCML in bamboo cell wall was removed at 200 ℃ and 16 MPa.-
Keywords:
- delignification /
- ultrastructure /
- bamboo /
- straw /
- CO2 supercritical fluid /
- GC-MS /
- TEM-EDXA
-
-
期刊类型引用(5)
1. 李玲琴，吕银华，刘江燕. 超临界CO_2脱除构皮木质素的研究. 仲恺农业工程学院学报. 2020(01): 28-37 . 
百度学术
2. 李萌，李鑫，童延斌，李婷婷，马玉萍，王婷. 甘草渣中木质素的超临界CO_2脱除工艺研究. 黑龙江畜牧兽医. 2019(01): 113-116 . 百度学术
3. 吴燕，韩岩，黄楠，吴佳敏，唐彩云，周季纯，黄琼涛. 脱木素工艺对透明木材性能的影响. 林业工程学报. 2019(06): 98-104 . 百度学术
4. 李新鑫，余学军，俞暾，蒋玉俭. 竹林环境中木质素降解菌株的分离鉴定. 竹子学报. 2016(02): 20-25 . 百度学术
5. 左林，程皓，刘江燕. 超临界CO_2萃取脱除甘蔗渣木质素的研究. 生物质化学工程. 2014(06): 44-49 . 百度学术
其他类型引用(4)
计量
- 文章访问数: 2263
- HTML全文浏览量: 182
- PDF下载量: 43
- 被引次数: 9
下载:
